Mars Reports 2014
The Nautical Institute has issued Mars Report No 34/2014 regarding the mis-communication between theengine crew and the bridge on a cargo vessel resulting in severe damage of the main engine.
Some 20 minutes after departure the cargo vessel’s main engine oil mist detector alarm sounded while the engine was at full ahead. The oil mist detector could not identify the cylinder unit causing the alarm and it was not connected to a shut down function. Hence, the engine crew tried to identify which unit was the problem while maintaining full ahead RPM. Subsequently, the main engine low lube oil alarm sounded. After communicating these problems to the bridge, the Master considered it inconvenient for the vessel to stop and the vessel sailed for approximately two hours before they finally stopped the main engine.
It was subsequently found that the main engine had suffered severe damage to the big end bearings and required renewal of the crank shaft; repairs that cost in the order of $1 million and left the vessel off-hire for more than 40 days.
The same vessel suffered a similar occurrence a few years earlier and sister vessels have also suffered similar crank shaft failures.
Lessons learned |
From a technical point of view, the engine crew appears not to have taken the proper action when the oil mist detector alarm sounded or when the low pressure alarm sounded later as they maintained the engine RPM and load. There may well be specific reasons for their actions, but what would you do on your vessel in a similar situation? Would your engine crew be able to see the possible consequences of their actions? Do your engine crew communicate openly and with reasonable clarity for a non-technician on the bridge to appreciate the situation they are facing in the engine room? Does your chief engineer effectively communicate the criticality of his engine condition in order for you to balance this information with considerations for the safety of the vessel (location, currents, weather, traffic)? Do your Technical Managers inform you of relevant situations on other vessels in your fleet, or of sister vessels with problems that may well happen to you? |
Source: The Nautical Institute/ Mars Report
The Mariners’ Alerting and Reporting Scheme (MARS) is primarily a confidential reporting system run by The Nautical Institute to allow full reporting of accidents (and near misses) without fear of identification or litigation. As a free service to the industry, MARS reports also regularly comprise alerts condensed from official industry sources, so that issues resulting from recent incidents can be efficiently relayed to the mariner on board. With access to the internet from vessels becoming more affordable, the MARS database is a valuable risk assessment, work planning, loss prevention tool and training aid for crew and management. MARS reports are held in a publicly-accessible database and can be accessed by clicking on the link below: Contact the Editor of MARS at [email protected] |